铸造涂料选购
1铸造涂料简介
铸造涂料是指涂敷在铸型型腔或型芯表面,以改善其表面耐火度、化学稳定性、抗金属冲刷性、抗粘砂性等性能的一种覆盖物,是重力型金属铸造的基础涂料。铸造涂料颗粒相对较粗,但绝热性能好,可防止铸造时铸件缺肉和冷隔,与铸件表面质量关系密切。铸造涂料可以减少铸件表面的机械粘砂和化学粘砂,减少铸件表面的夹砂和冲砂,改善铸件的表面性能和内部质量。
一般情况下,铸造涂料采用浸涂法,具有生产效率高、节省涂料、涂层均匀以及对涂料的要求不高、操作简便,不需要特殊设备等优点,在实际应用中深受欢迎。铸造涂料适用于金属模具、细薄截面铸件和大平面铸件,也适用于供料口、轮毂、活塞、连杆、气缸等。
2铸造涂料性能
铸造涂料性能主要有良好的透气性、耐火度、液态吸附性、悬浮性、触变性、涂挂性、流平性以及适当的渗透性等。
1、铸造涂料起隔热,均衡温度,免除因金属液的冲击与腐蚀性从而达到保护摸具和延长摸具使用寿命可长达1/3以上;
2、防止铸件产品因局部冷却过快而造成的开裂和白口铁形成;
3、吸附时间长达7天之久,透气性好,每次脱模可用乙炔烟熏处理来代替脱模剂的使用,浇注一个铸件烟熏一次即可。
3铸造涂料优势
1、与磷酸盐涂料相比,铸造涂料特有的物理性能决定了它的优势;
2、透气好。
3、保温隔热效果明显,熔点在1650℃以上;
4、喷吐后附着力强且不宜剥落,通常一周后才需修补,铸造涂料不需要象其它涂料一样每次开摸要喷涂,省却每天因喷补涂料而拆装摸具的繁琐工作;
5、涂刷点燃后,型、芯外表的涂料层可自行烘干,不必进烘干窑;
6、使用方便,生产周期短,大大提高生产效益;
7、相对而言价格便宜,大大降低了因使用醇基涂料或进口涂料所带来昂贵的生产铸造成本。
4铸造涂料使用
铸造涂料的使用方法铸造涂料的主要有刷、浸、喷、流、静电喷等涂敷的方法。每种涂敷方法需要了解不同的涂料性能,采用最好的涂敷方法,这样对涂料的应用比较好。
1、刷涂法:要求涂料的流型是触变性流体,刷涂要求工人有熟练的技术,这样生产效率比较低。
2、浸涂法:是将砂芯用手工或机械浸没在涂料槽中,用振动或旋转的方法去除多余涂料。
3、喷涂法:这是比较快的施涂法。使用醇基涂料时,洒精雾化散入空气的量大,会对环境产生一定的污染,要注意使用。
4、流涂法:这是快速的方法,适合较大砂型和砂芯生产线的要求,大家要注意运用。
5、静电喷涂法:采用粉末涂料,借高压直流电形成强大静电场使粉末涂料微粒在喷枪头部的电晕放电区带电,在电场力和风力作用下向异极性砂芯(型)表面迅速集积成涂层,然后加热使涂料中粘结剂软化重熔建立涂层强度。此法适用于尺寸较狭小的凹坑或狭缝不易徐敷上涂料的场合。
碳钢铸造涂料使用方法
首先在使用这种涂料之前,一定要进行均匀搅拌,再开始进行涂刷,对于铸件来说,一般只需要涂刷一遍,就可以了,在涂刷之后,然后就对这种涂料进行点火,慢慢就可以烧干,如果是厚大件的产品,就可以进行多遍涂刷,对于易粘砂部位也应该进行很多遍的涂刷,不过应该注意的就是,对于铸造涂料,从涂刷第二遍的时候,要先在停放两分钟或者是四分钟的样子,然后就开始点火,那么就有更好的效果。当然,对于其它的涂敷方法也比较适用。
5地中海装修效果图
6防火板施工工艺
安装前须知:
1、在安装板材时,材料必须使其达到室温标准并维持稳定的温度。材料不得安装于和正常使用场所极为不同之温度的地点。
2、防火板装饰平板及天花板属于室内装修产品,设计用于一般正常使用空间在15℃-30℃度安装,相对湿度不可超过70%。所有石膏、水泥、磨石子或其他潮湿性的工程都必须放置妥当。在安装之前,进行中或完成后,暖气通风及冷空调系统都得先行安装妥及可使用,以便维持正常的温度。
3、建议勿使用保温材料覆盖于天花板或以天花板支撑保温材料。在高相对湿度状态下,如天花板承受附加重量,可能导致天花板下陷。若工程确需用如此之保温材料,必须用于正常使用环境(温度15℃-30℃,相对湿度最高达到70%)其保温材料之重量限制为最高不得超过1.269kg/m2,惟有卷装保温材料可被使用。而且务必垂直安装于骨架支点中,以支撑保温材料重量。
接下来介绍一般的防火板材装修流程
1.基层处理 将基层表面灰尘、水泥余浆清理干净,将额外突起处剔除。
2.将墙面整体涂刷一遍界面剂
3.检查墙体平整度时,如遇墙面凹凸超过20mm以上,须抹灰找平和剔凿处理(由总包方负责)
4.如墙面有陶粒砖,加气块的地方,须由总包方用1:3的水泥砂浆加一层12.7×12.7mm的热镀锌钢丝网做找平,厚度不小于15mm。
5.贴板前在墙面找一至高点放垂直线和平行线(凹凸处经甲方同意可用异形板进行施工)。
6.粘贴方法用框条粘贴法粘贴,粘贴砂浆面积不得少于50%-70%(如外墙粘砖的话,粘贴砂浆不得少于60%-80%,还必须用12.7×12.7mm的热镀锌钢丝网加固)。
7.门洞、窗洞、女儿墙须按翻包粘贴法粘贴,粘贴板材时门窗角必须将板材切割成刀把型进行粘贴。板材两边长度不得小于300mm。另外门、窗洞口四周附加一层45°角耐碱玻纤网格布(200×400mm)。
8.固定锚固件时先用电锤打眼,打眼深度不得小于基层40mm,固定时必须用电动手枪钻将锚栓钢螺钉拧进,不得用鎯头直接敲入,锚栓数量每平方米不低于5-6个。
9.抹抗裂砂浆时厚度不得小于4mm,后将玻纤网格布轻压在抗裂砂浆表面,再用2米杠尺在玻纤网格布面上将不平整和多余的抗裂砂浆抹去或刮平,最后再薄抹一层罩面砂浆,厚度不得少于2mm.(注:抗裂砂浆低于4mm,就有可能显现保温板的痕迹(以上方法仅供参考,具体需按照实际需求调整)
最后,防火板的保养也是非常关键的一个程序,在装修好防火板材之后。日常保养过程延续了防火板的寿命和使用安全。防火板的维护保养其实非常简单,大家在清洁的时候一定不要使用太过于粗糙的东西,特别是钢丝球绝对不能用来清洁防火板,否则很容易划伤防火板影响美观,我们只需要用棉布清洗就行。
7玻璃推拉门安装
1、挂式推拉门由于先装轨道盒再贴砖,外露式轨道盒与砖交接处不好处理,给施工带来一定的难度。由于轨道承受了一定的压力,砖也受力,时间一久,容易导致轨道旁的砖开裂。另外,如果在厨房卫生间等空间内,轨道盒处容易藏污纳垢,油烟积灰等落在上面,给打扫卫生带来麻烦。
2、推拉门上部的轨道盒尺寸要保证在高12厘米,宽9厘米。像窗帘盒一样,轨道盒内安装轨道,可以将推拉门悬挂在轨道上。如今大多数门或门洞的高度是1.95至2.15米。经验表明,当门的高度低于1.95米时,不管人的身高是多少,都会感觉很压抑,不舒服。因此,在做推拉门时,高度最少要在195+12=207厘米以上,有足够空间做轨道盒才可以考虑做推拉门。否则只能是外部悬挂,即轨道盒露在外面,肯定不美观,而且时间一久,门与墙面的缝隙会变大。
3、推拉门的宽度有讲究。正常门的黄金尺寸在80厘米×200厘米左右,在这种结构下,门是相对稳定的。如果有高于200厘米的高度,甚至更高的情况下做推拉门,最好在面积保持不变的前提下,将门的宽度缩窄或多做几扇推拉门,保持门的稳定和使用安全性。
4、慎用由落地到顶的推拉门(明吊轨道盒)。由于推拉时摆动幅度过大,时间一长推拉门容易变形,变形后门就无法开启,也就意味着不可修复和无法使用。
5、由于滑动门与墙壁或柜体两侧接触,因此,在接触的位置不要有其它的物件阻挡滑动门的关闭。比如柜体内抽屉的位置要避开推拉门相交处,且要高于底板至少1cm;折门柜体内的抽屉距侧壁至少15cm此处还要特别注意墙上的电源开关和插座,若阻挡了滑动门的关闭,应改动开关和插座的位置。
6、无论您做任何材料的地面,都要保证水平,门洞的四壁也要保持水平和垂直。否则门在安装完成后会出现歪斜的现象。可调节的误差不大于10mm。
7、在安装位置请不要安装踢角线,石膏线可安装在壁柜上方的封板上,若门直接到顶则不要安装石膏线。
8、5毫米厚度以下的地毯将所在位置的地毯裁掉直接粘贴下轨。5毫米厚度以上的地毯如安装双轨可直接用螺丝固定在地毯上:如安装单轨则必须将所在位置的地毯裁掉,将地毯处事先放置3-5毫米厚的木条,以便将单轨直接粘贴在上面。
9、木地板与瓷砖的结合处,这种情况大多出现在阳台与客厅以及卧室和客厅之间,解决办法如下:1、尽量将下轨安装在一种材料上。2、将两种材料中间另加一条与下轨同宽的木板或大理石。厨房部位也可用门槛石。
8玻璃推拉门配件
玻璃推拉门配件在制作之前我们需要准备很多的材料,没有足够的材料我们是很难将玻璃推拉门制作好的,一般制作玻璃推拉门需要准备滑轨、把手、木框、玻璃胶等等的材料,因为使用玻璃,所以玻璃胶是一个不可或缺的材料,其他如滑轨、把手都应该做好准备。
转载原文地址:https://baike.tobosu.com/view/n16238.html
转载原文地址:https://baike.tobosu.com/view/n5417.html
转载原文地址:https://baike.tobosu.com/view/n1204.html
转载原文地址:https://baike.tobosu.com/view/n37.html
转载原文地址:https://baike.tobosu.com/view/n21831.html
转载原文地址:https://baike.tobosu.com/view/n2875.html
转载原文地址:https://baike.tobosu.com/view/n16177.html
转载原文地址:https://baike.tobosu.com/view/n20922.html
转载原文地址:https://baike.tobosu.com/view/n1603.html
转载原文地址:https://baike.tobosu.com/view/n6605.html
转载原文地址:https://baike.tobosu.com/view/n21416.html
转载原文地址:https://baike.tobosu.com/view/n4984.html
转载原文地址:https://baike.tobosu.com/view/n6479.html
转载原文地址:https://baike.tobosu.com/view/n18476.html
转载原文地址:https://baike.tobosu.com/view/n1450.html
转载原文地址:https://baike.tobosu.com/view/n18229.html
转载原文地址:https://baike.tobosu.com/view/n6790.html
转载原文地址:https://baike.tobosu.com/view/n71.html
转载原文地址:https://baike.tobosu.com/view/n2595.html
转载原文地址:https://baike.tobosu.com/view/n4328.html
转载原文地址:https://baike.tobosu.com/view/n20931.html
转载原文地址:https://baike.tobosu.com/view/n5953.html
转载原文地址:https://baike.tobosu.com/view/n22317.html
转载原文地址:https://baike.tobosu.com/view/n3083.html
转载原文地址:https://baike.tobosu.com/view/n19286.html
转载原文地址:https://baike.tobosu.com/view/n1415.html
转载原文地址:https://baike.tobosu.com/view/n21035.html
转载原文地址:https://baike.tobosu.com/view/n16545.html
转载原文地址:https://baike.tobosu.com/view/n21868.html
转载原文地址:https://baike.tobosu.com/view/n2381.html
转载原文地址:https://baike.tobosu.com/view/n21384.html
转载原文地址:https://baike.tobosu.com/view/n2051.html
转载原文地址:https://baike.tobosu.com/view/n3028.html
转载原文地址:https://baike.tobosu.com/view/n3684.html
转载原文地址:https://baike.tobosu.com/view/n18189.html
转载原文地址:https://baike.tobosu.com/view/n21852.html
转载原文地址:https://baike.tobosu.com/view/n20289.html
转载原文地址:https://baike.tobosu.com/view/n3467.html
转载原文地址:https://baike.tobosu.com/view/n5925.html
转载原文地址:https://baike.tobosu.com/view/n21450.html
转载原文地址:https://baike.tobosu.com/view/n21197.html
转载原文地址:https://baike.tobosu.com/view/n19481.html
转载原文地址:https://baike.tobosu.com/view/n21412.html
转载原文地址:https://baike.tobosu.com/view/n20651.html
转载原文地址:https://baike.tobosu.com/view/n2120.html
转载原文地址:https://baike.tobosu.com/view/n16452.html
转载原文地址:https://baike.tobosu.com/view/n5677.html
转载原文地址:https://baike.tobosu.com/view/n2601.html
转载原文地址:https://baike.tobosu.com/view/n5583.html
转载原文地址:https://baike.tobosu.com/view/n18441.html
转载原文地址:https://baike.tobosu.com/view/n16222.html
转载原文地址:https://baike.tobosu.com/view/n17746.html
转载原文地址:https://baike.tobosu.com/view/n6254.html
转载原文地址:https://baike.tobosu.com/view/n21941.html
转载原文地址:https://baike.tobosu.com/view/n67.html
转载原文地址:https://baike.tobosu.com/view/n3843.html
转载原文地址:https://baike.tobosu.com/view/n3537.html
转载原文地址:https://baike.tobosu.com/view/n18466.html
转载原文地址:https://baike.tobosu.com/view/n3210.html
转载原文地址:https://baike.tobosu.com/view/n20888.html
转载原文地址:https://baike.tobosu.com/view/n2444.html
转载原文地址:https://baike.tobosu.com/view/n21585.html
转载原文地址:https://baike.tobosu.com/view/n2248.html
转载原文地址:https://baike.tobosu.com/view/n21605.html
转载原文地址:https://baike.tobosu.com/view/n1876.html
转载原文地址:https://baike.tobosu.com/view/n16900.html
转载原文地址:https://baike.tobosu.com/view/n22110.html
转载原文地址:https://baike.tobosu.com/view/n3409.html
转载原文地址:https://baike.tobosu.com/view/n18030.html
转载原文地址:https://baike.tobosu.com/view/n18460.html
转载原文地址:https://baike.tobosu.com/view/n5448.html
转载原文地址:https://baike.tobosu.com/view/n122.html
转载原文地址:https://baike.tobosu.com/view/n2096.html
转载原文地址:https://baike.tobosu.com/view/n19194.html
转载原文地址:https://baike.tobosu.com/view/n2202.html
转载原文地址:https://baike.tobosu.com/view/n21221.html
转载原文地址:https://baike.tobosu.com/view/n20493.html
转载原文地址:https://baike.tobosu.com/view/n1449.html
转载原文地址:https://baike.tobosu.com/view/n6003.html
转载原文地址:https://baike.tobosu.com/view/n19203.html
转载原文地址:https://baike.tobosu.com/view/n5095.html
转载原文地址:https://baike.tobosu.com/view/n17770.html
转载原文地址:https://baike.tobosu.com/view/n1403.html
转载原文地址:https://baike.tobosu.com/view/n18506.html
转载原文地址:https://baike.tobosu.com/view/n20910.html
转载原文地址:https://baike.tobosu.com/view/n137.html
转载原文地址:https://baike.tobosu.com/view/n22337.html
转载原文地址:https://baike.tobosu.com/view/n6927.html
转载原文地址:https://baike.tobosu.com/view/n2037.html
转载原文地址:https://baike.tobosu.com/view/n22027.html
转载原文地址:https://baike.tobosu.com/view/n2641.html
转载原文地址:https://baike.tobosu.com/view/n23629.html
转载原文地址:https://baike.tobosu.com/view/n3601.html
转载原文地址:https://baike.tobosu.com/view/n17238.html
转载原文地址:https://baike.tobosu.com/view/n5668.html
转载原文地址:https://baike.tobosu.com/view/n20241.html
转载原文地址:https://baike.tobosu.com/view/n6395.html
转载原文地址:https://baike.tobosu.com/view/n23676.html
转载原文地址:https://baike.tobosu.com/view/n22265.html
转载原文地址:https://baike.tobosu.com/view/n3092.html
转载原文地址:https://baike.tobosu.com/view/n23565.html
转载原文地址:https://baike.tobosu.com/view/n1283.html
转载原文地址:https://baike.tobosu.com/view/n2389.html
转载原文地址:https://baike.tobosu.com/view/n21775.html
转载原文地址:https://baike.tobosu.com/view/n5987.html
转载原文地址:https://baike.tobosu.com/view/n5935.html
转载原文地址:https://baike.tobosu.com/view/n20240.html
转载原文地址:https://baike.tobosu.com/view/n22117.html
转载原文地址:https://baike.tobosu.com/view/n3014.html
转载原文地址:https://baike.tobosu.com/view/n18199.html
转载原文地址:https://baike.tobosu.com/view/n22136.html
转载原文地址:https://baike.tobosu.com/view/n23670.html
转载原文地址:https://baike.tobosu.com/view/n6353.html
转载原文地址:https://baike.tobosu.com/view/n20248.html
转载原文地址:https://baike.tobosu.com/view/n5262.html
转载原文地址:https://baike.tobosu.com/view/n19582.html
转载原文地址:https://baike.tobosu.com/view/n16415.html
转载原文地址:https://baike.tobosu.com/view/n17182.html
转载原文地址:https://baike.tobosu.com/view/n17517.html
转载原文地址:https://baike.tobosu.com/view/n18141.html
转载原文地址:https://baike.tobosu.com/view/n4647.html
转载原文地址:https://baike.tobosu.com/view/n1983.html
转载原文地址:https://baike.tobosu.com/view/n1885.html
转载原文地址:https://baike.tobosu.com/view/n6296.html
转载原文地址:https://baike.tobosu.com/view/n3343.html
转载原文地址:https://baike.tobosu.com/view/n19505.html
转载原文地址:https://baike.tobosu.com/view/n19246.html
转载原文地址:https://baike.tobosu.com/view/n19465.html
转载原文地址:https://baike.tobosu.com/view/n2090.html
转载原文地址:https://baike.tobosu.com/view/n18538.html
转载原文地址:https://baike.tobosu.com/view/n21642.html
转载原文地址:https://baike.tobosu.com/view/n18277.html
转载原文地址:https://baike.tobosu.com/view/n21885.html
转载原文地址:https://baike.tobosu.com/view/n4548.html
转载原文地址:https://baike.tobosu.com/view/n4011.html
转载原文地址:https://baike.tobosu.com/view/n4878.html
转载原文地址:https://baike.tobosu.com/view/n16487.html
转载原文地址:https://baike.tobosu.com/view/n6143.html
转载原文地址:https://baike.tobosu.com/view/n22430.html
转载原文地址:https://baike.tobosu.com/view/n18020.html
转载原文地址:https://baike.tobosu.com/view/n18530.html
转载原文地址:https://baike.tobosu.com/view/n22.html
转载原文地址:https://baike.tobosu.com/view/n17180.html
转载原文地址:https://baike.tobosu.com/view/n2400.html
转载原文地址:https://baike.tobosu.com/view/n22548.html
转载原文地址:https://baike.tobosu.com/view/n17921.html
转载原文地址:https://baike.tobosu.com/view/n6803.html
转载原文地址:https://baike.tobosu.com/view/n2787.html
转载原文地址:https://baike.tobosu.com/view/n4826.html
转载原文地址:https://baike.tobosu.com/view/n20310.html
转载原文地址:https://baike.tobosu.com/view/n18447.html
转载原文地址:https://baike.tobosu.com/view/n2131.html
转载原文地址:https://baike.tobosu.com/view/n4942.html
转载原文地址:https://baike.tobosu.com/view/n2821.html
转载原文地址:https://baike.tobosu.com/view/n18204.html
转载原文地址:https://baike.tobosu.com/view/n1205.html
转载原文地址:https://baike.tobosu.com/view/n6616.html
转载原文地址:https://baike.tobosu.com/view/n6829.html
转载原文地址:https://baike.tobosu.com/view/n21490.html
转载原文地址:https://baike.tobosu.com/view/n17513.html
上述内容来自用户自行上传或互联网,如有版权问题,请联系zxcq@corp.to8to.com 。